Focus Active X Edition Mhev

Recent owner-reported faults

1. 20 May 2022

   Report of Sync3 system freezing on 2018 Focus. Occasionally and for no obvious reason the touchscreen freezes. The only way to get it all to work again seems to be to turn the car off for at least fifteen minutes or more.

2. 1 Feb 2021

   Report of “Exhaust filter limit reached. Drive to clean now" warning message on 2018 Focus 1.0- EcoBoost. Ford suggests driving at a varied range of conditions, including motorway for a minimum of 20 minutes or until the message disappears. Driver should also maintain engine speed between 1500 and 4000rpm.

3. 17 Dec 2019

   Numerous electrical faults reported in new Ford Focus 1.5 Ecoboost 8-speed automatic since summer 2019: "Charging System Alert!! Service Now! warnings, displays changing randomly, the seatbelt warning alarms going on even when the engine was switched off, and so on. Fearing imminent breakdown owner called out the RAC. After connecting his diagnostic interrogator to the car it revealed dozens of different faults including low voltage to the brake servos and steering servos etc. etc. After a lot of head scratching he looked under the bonnet and found a faulty battery earth connection. The earth bolt was only partly inserted into the body, cross-threaded and the cable was making and breaking connection.

4. 17 Nov 2019

   Report of judder from stop/start system on 2018 Ford Focus 1.5ST automatic. Also judders when accelerating hard from T junctions.

5. 26 Oct 2019

   Report of replacement steering rack for April 2019 Ford Focus ST Line X on back order. Power steering rack failed and owner has been without car since 7th October, but provided with a courtesy car.

6. 15 Sep 2019

   Report of delivery of Ford Focus Estate 2.0 TDCI x Ecolube Auto 19B with panoramic roof in dark grey metallic ordered on 21-5-2019 being held up, probably due to RDE1 emissions testing. Originally supposed to have been delivered in August (on a 19 reg), delivery then stretched to October 2019, then "no build date until December 2019".

7. 23 Aug 2019

   Report of "small browny red light to the right of the milometer at the top of the dash display that very occasionally comes on for three of four seconds every 300 to 400 miles" in new Ford Focus 1.5 3cyl Ecoboost 182 Vignale 8-speed auto. Explanation is that the light comes on to show the engine going lean. The PPF works differently from a DPF and works a little and relatively frequently by comparison to a DPF. It only comes on a typical motorway journey. Owner drove from Newcastle to Leamington Spa last week, the fuel consumption was 50.1mpg on way down and 48.2 on way back. This is about 5 to 6mpg better than his previous 1.5 4cyl 182hp manual.

8. 16 Apr 2019

   Report of clutch failure of new, 2019 Ford Focus in just 450 miles.

9. 13 Feb 2019

   Third report of Petrol Particulate Filter light coming on, this time in a 2019 Ford Focus ST Line 1.0 EcoBoost 125 at just 300 miles from new. Owner made a run of 15 miles dual carriage way and motorway and it came back on when he made the return journey. Booked into Ford for diagnostic next week. Ford dealer carried out a static forced regeneration of the filter. Mechanic said he had it up to 750 degrees to clean it. Manual says it should clean at 550 degrees.

10. 23 Jan 2019

    Report of many electronic systems on a new September 2018 Ford Focus either malfunctioning or not working at all: "almost immediately there were problems with the touch screen and reversing camera. It displays warnings such as 'collision assist warning service needed' and several other messages randomly. The rear camera often remains on when driving forward again and then the whole system crashes. Despite numerous visits to the dealer no one can find the cause of the fault."

11. 2 Jan 2019

    Report of several minor faults with the electrics of a new Ford Focus forcing ower to park it on his driveway for 3 weeks waiting for parts. The latest fault affects the engine performance, and leaves owner reluctant to take the car out.

12. 20 Dec 2018

    Report of dashboard of new Ford Focus 1.0 Ecoboost 125 with 2,000 miles on 5 occasions showing 'exhaust filter at limit. Drive to clean'. On each occasion, owners carried on driving the car and after a short period the display reverted back to normal. Country driven car and driven briskly. But owner reports. "The management display on the dash keeps telling us to change up, yet this condition implies that really you need to change down." This is the result of conflicting EC requirements. It is a Type Approval requirement that new manual cars have to have an indicator suggesting changes. But if this is applied during the first 5-10 mies after a cold start the PPF will not necessarily get hot enough to clear the cold start particulates. Suggested running at up to 2000rpm for the first 5-10 miles.

Source: honestjohn.co.uk · 15 reports indexed, top 12 shown