Chrysler
Voyager
1,735 MOT tests analysed. runs below the UK fleet average — here's where Voyagers pass, fail, and end up on the retest sheet.
That's 17.3 points below the UK fleet average across our 1,984 tracked models — buyers should expect more first-time fails than the typical UK car.
Pass
60.2%
Pass-after-fix
7.6%
Fail
30.4%
Avg miles
116,130
Pass + Pass-after-fix + Fail = 100%
Some examples of this model are borderline — a small number of diesels were certified Euro 6 before September 2015. Check your registration on the government's ULEZ checker to be certain. Daily charges if driven in the zone: London £12.50 · Birmingham £8.00 · Bristol £9.00 .
The picture
Voyager: a below-average pass rate worth digging into
Across 1,630 MOT tests, the Voyager returns 63.9% first-time pass — well below the UK fleet average. The single most-logged Major fail is a number-plate lamp out. A defective headlamp lens and a weak handbrake round out the top three. Average tested mileage sits at 114,377, which is the lens to read those failure rankings through. If you own one and the next test is close, the ranked list below is a sensible pre-test checklist.
ABI Insurance Group
Group 20–28
Around the UK fleet average for insurance cost. Lower groups cost less to insure; UK fleet average is around Group 22.
Source: ABI Group Rating Panel · administered by Thatcham Research · groups cover standard variants; performance trims may sit higher. Browse all insurance groups →
20–28
out of 50
Top ten reasons for rejection.
Filter failures:
Hide categories
Tick a category to hide it from rankings sitewide. Saved in this browser only.
- 01
Headlamp reflector or lens slightly defective
158 occurrences · 9.1% of tests
- 02
A rear registration plate lamp or light source missing or inoperative in the case of multiple lamps or light sources
130 occurrences · 7.5% of tests
- 03
The strength or continuity of the load bearing structure within 30cm of any sub-frame, spring or suspension component mounting (a 'prescribed area') is significantly reduced or inadequately repaired
98 occurrences · 5.6% of tests
- 04
Parking brake efficiency below minimum requirement
91 occurrences · 5.2% of tests
- 05
A lamp missing, inoperative or in the case of a multiple light source more than 1/2 not functioning
83 occurrences · 4.8% of tests
- 06
Windscreen or window damaged or seriously discoloured but not adversely affecting driver's view
70 occurrences · 4.0% of tests
- 07
The aim of a headlamp is not within limits laid down in the requirements
61 occurrences · 3.5% of tests
- 08
Parking brake efficiency less than 50% of the required value
56 occurrences · 3.2% of tests
- 09
Warning device shows system malfunction
55 occurrences · 3.2% of tests
- 10
Parking brake inoperative on one side
55 occurrences · 3.2% of tests
Counts cover Major and Dangerous defects logged at test. Advisory items excluded so this shows why a car was rejected, not just what the tester flagged in passing.
Worst-case fix budget · top 2 failures
£18–£115
If every one of this Voyager's most-logged Major fails hit at the same MOT, that's the real-world UK garage range. Reality is usually one or two items, not all of them. Open the estimator →
Try the calculator
Build your own retest budget.
Tools that pre-empt a retest.
Picked against this car's top failure patterns. Affiliate links to Amazon UK — we earn a small cut at no cost to you. Disclosed up-front, doesn't shape the data.
Item 01 · Amazon UK
Headlight restoration kit
Yellowed lenses fail the light-output test. A restoration kit lifts the haze in an afternoon for £20.
Search Amazon UK
Item 02 · Amazon UK
H7 / W21W bulb pack
A spare-bulb kit lives in the boot. Test morning is not the time to find your stop-lamp's gone.
Search Amazon UK
My Motor World · affiliate
Parts & supplies for this fix
Affiliate links — small commission, no extra cost to you.
Carlube Triple R
Carlube Triple R 5W-20 Chrysler Fully Synthetic Engine Oil R-TEC 15 1L
£10.25
View at My Motor World →
Motor World
Motor World Chrysler 300C 2005- Car Floor Mat Set
£32.99
View at My Motor World →
Motor World
Motor World Chrysler Jeep Grand Cherokee 2005-2014 Car Floor Mat Set
£32.99
View at My Motor World →
Motor World
Motor World Chrysler Ypsilon 2011- Car Floor Mat Set
£32.99
View at My Motor World →
Click Mechanic · affiliate
Book a mobile mechanic
Affiliate links — small commission, no extra cost to you.
Mobile mechanic · UK-wide
Book a mechanic at your door.
Fixed-price quotes upfront. No garage needed. Click Mechanic sends a vetted local mechanic to you — home, work, or roadside.
Recall history
7 UK recalls on record.
The Voyager has 7 official UK vehicle recalls covering defect details, remedies, and affected build dates.
Buying or keeping a Voyager?
Use the failure ranking as a pre-test checklist or a haggling lever. Treat the headline pass rate as a fleet-wide trend, not a guarantee on any individual car.
If you own a Voyager and your last MOT looked nothing like the ranked failures above, that's normal — individual cars vary widely. The ranking shows the patterns testers flag most often across the country.