Photo: Vauxford, CC BY-SA 4.0
Volkswagen
Polo Active Tsi
2,788 MOT tests analysed. sits above the UK fleet average — here's where Polo Active Tsis pass, fail, and end up on the retest sheet.
That's 16.0 points above the UK fleet average across our 1,984 tracked models — a confident result.
Pass
93.5%
Pass-after-fix
2.0%
Fail
4.4%
Avg miles
21,792
Pass + Pass-after-fix + Fail = 100%
Petrol cars first registered from January 2006 meet Euro 4 — compliant in London ULEZ, Birmingham CAZ, Bristol CAZ, and Glasgow LEZ.
The picture
Polo Active Tsi: a strong MOT record by UK norms
Across 2,788 MOT tests, the Polo Active Tsi returns 93.5% first-time pass — comfortably ahead of the UK fleet average. The single most-logged Major fail is windscreen damage. A seriously damaged tyre and a defective wiper blade round out the top three. Average tested mileage sits at 21,792, which is the lens to read those failure rankings through. If you own one and the next test is close, the ranked list below is a sensible pre-test checklist.
Top ten reasons for rejection.
Filter failures:
Hide categories
Tick a category to hide it from rankings sitewide. Saved in this browser only.
- 01
Windscreen or window damaged or seriously discoloured but not adversely affecting driver's view
29 occurrences · 1.0% of tests
- 02
A tyre seriously damaged
28 occurrences · 1.0% of tests
- 03
Wiper blade defective
24 occurrences · 0.9% of tests
- 04
Steering rack gaiter or ball joint dust cover damaged or deteriorated
16 occurrences · 0.6% of tests
- 05
Tyre tread depth not in accordance with the requirements
15 occurrences · 0.5% of tests
- 06
Wiper blade missing or obviously not clearing the windscreen
10 occurrences · 0.4% of tests
- 07
Windscreen washers not working or not providing sufficient fluid to clear the windscreen
9 occurrences · 0.3% of tests
- 08
A tyre cords visible or damaged
9 occurrences · 0.3% of tests
- 09
a brake lining or pad worn below 1.5mm
6 occurrences · 0.2% of tests
- 10
A brake on any wheel grabbing severely
6 occurrences · 0.2% of tests
Counts cover Major and Dangerous defects logged at test. Advisory items excluded so this shows why a car was rejected, not just what the tester flagged in passing.
Worst-case fix budget · top 3 failures
£160–£380
If every one of this Polo Active Tsi's most-logged Major fails hit at the same MOT, that's the real-world UK garage range. Reality is usually one or two items, not all of them. Open the estimator →
Try the calculator
Build your own retest budget.
Tools that pre-empt a retest.
Picked against this car's top failure patterns. Affiliate links to Amazon UK — we earn a small cut at no cost to you. Disclosed up-front, doesn't shape the data.
Item 01 · Amazon UK
Bosch Aerotwin wiper blades
Cheap wipers fail the test on smear streaks. Bosch Aerotwins last a winter and clear a screen properly.
Search Amazon UK
Item 02 · Amazon UK
Digital tyre-tread depth gauge
Five quid for a gauge beats £150 for a retest. UK MOT minimum is 1.6mm — most testers fail anything below 2mm to be safe.
Search Amazon UK
My Motor World · affiliate
Parts & supplies for this fix
Affiliate links — small commission, no extra cost to you.
Hycote
Hycote Touch Up Colour Paint Brush Volkswagen Shadow Blue Metallic 12.5ml
£6.59
View at My Motor World →
Hycote
Hycote Touch Up Colour Paint Brush Volkswagen Reflex Silver Metallic 12.5ml
£6.59
View at My Motor World →
Hycote
Hycote Touch Up Colour Paint Brush Volkswagen Black 12.5ml
£6.59
View at My Motor World →
Hycote
Hycote Touch Up Colour Paint Brush Volkswagen Mars Red 12.5ml
£6.59
View at My Motor World →
Click Mechanic · affiliate
Book a mobile mechanic
Affiliate links — small commission, no extra cost to you.
Mobile mechanic · UK-wide
Book a mechanic at your door.
Fixed-price quotes upfront. No garage needed. Click Mechanic sends a vetted local mechanic to you — home, work, or roadside.
Owner reports · Honest John
What owners actually report.
Verbatim faults logged by owners on honestjohn.co.uk over recent years. We didn't summarise — these are the words people typed in.
Where it falls short
Owner reports (49 entries) flag recurring issues with DSG/gearbox, brake discs/pads, DPF.
Recent owner-reported faults
- 3 Mar 2016
Report of EPC light coming on in 2010 Polo 1.2 TSI and engine becoming sluggish. EPC = Electronic Power Control, which is the drive by wire system between the accelerator pedal and the engine. Local garage tried various remedies all of which failed but when the light comes on the reason is usually a duff brake light switch that VW uses to shut down the throttle when the brakes are on and is the reason why DSGs are often sluggish off the mark.
- 6 Feb 2016
Window winding cables snapped inside the doors of a 2010 Polo, within days of the same thing happening to another reader in a similar age SEAT Ibiza.
- 31 Jan 2016
Report of 2014 Polo 1.2 TSI DSG changing down three gears at a time on an incline.
- 30 Dec 2015
Report of premature failure of front brake discs and pads on 2 year old Polo at 14,500 miles. Replacement cost was £259.
- 9 Dec 2015
Report of repeated failure of satnav in 2014 Polo and dealer unable to fix.
- 9 Dec 2015
'Official' CO2 and fuel economy figures of 2016MY Polo 1.0l TSI BlueMotion 70kW EU6 Seven-speed (DSG) to be reviewed but true figures are only very slightly worse.
- 27 Aug 2015
Complaint of juddering of brakes of January 2015 Polo, diagnosed by dealer as warping, but possibly caused by the old Polo problem of material from the pads adhering to the discs.
- 27 Aug 2015
Timing chain failure reported on 2010 Polo 1.2 (3-cylinder or 4-cylinder not mentioned, but assumed to be 1.2 TSI) at 40,000 miles. Bought independently and has non-VW service history.
- 8 Jul 2015
Failure reported of 1.4 16v engine of 2009 VW Polo at 26,000 miles. Dealer said cost £1943 to fix, involving 12 hours labour work, replacing the engines valves, stripping the engine for proper clean, then rebuilding the engine.
- 5 Jul 2015
Complaint of noisy wiper motor on new Polo 1.2. Three others in the showroom also noisy. Could be a bad batch of wiper motors.
- 17 Jun 2015
Reliability issues with 2012 Polo bought 2nd-hand (that might have been inherited from the previous use of the car): Needed brake pads, had faulty lights (although they all work), engine management system keeps going faulty and the catalytic converter is about to go.
- 28 May 2015
Switch on heater/aircon fan of 2010 Polo failed. New fan motor prescribed at £340.
Source: honestjohn.co.uk · 30 reports indexed, top 12 shown
Buying or keeping a Polo Active Tsi?
Use the failure ranking as a pre-test checklist or a haggling lever. Treat the headline pass rate as a fleet-wide trend, not a guarantee on any individual car.
If you own a Polo Active Tsi and your last MOT looked nothing like the ranked failures above, that's normal — individual cars vary widely. The ranking shows the patterns testers flag most often across the country.