Master

All recall notices.

1. Accelerator Pedal Assembley

   R/2025/520 · 4 Dec 2025

   4 Dec 2025

   Defect

   For certain vehicles the end-stop breaking force of the accelerator pedal is lower than the intended technical specification. This may lead to a rupture of the accelerator pedal assembly if the pedal is pressed vigorously.

   Remedy

   Replacement of the accelerator pedal assembly.

   Build window

   Built 18 Sep 2024 – 29 Aug 2025

   ~4,850 vehicles affected

2. Possible abrasion wear of the fuel supply pipe

   R/2024/295 · 26 Jul 2024

   26 Jul 2024

   Defect

   On affected vehicles there is a possibility of abrasive wear of the fuel supply line. This can cause one or several possible effects: Fuel odour in the passenger compartment High fuel consumption Fuel leak in the engine compartment visible under the vehicle Risk of fire.

   Remedy

   Check the fuel pipe and replace if required. All affected vehicles will be fitted with a mounting clip to protect the fuel pipe.

   Build window

   Built 23 Sep 2014 – 27 Sep 2024

   ~2,796 vehicles affected

3. Checking the secure mounting of the reducer gearbox.

   R/2024/148 · 5 Apr 2024

   5 Apr 2024

   Defect

   On affected vehicles there is a potential risk the electrical powertrain may not be secured correctly.

   Remedy

   Check and change the electric traction reducer mounting if necessary.

   Build window

   Built 29 Jul 2020 – 16 Jun 2023

   ~90 vehicles affected

4. THE FIXED SPEED LIMITER IS INOPERATIVE

   R/2020/119 · 5 May 2020

   5 May 2020

   Defect

   Due to the incorrect calibration of the injection computer the fixed speed limiter is inoperative.

   Remedy

   Re-program the injection computer.

   Build window

   Built 12 Sep 2019 – 8 Nov 2019

   ~134 vehicles affected

5. POWER STEERING WARNING LAMP MAY NOT ILLUMINATE

   R/2018/143 · 19 Jun 2018

   19 Jun 2018

   Defect

   No warning light on the dashboard should the power steering fail

   Remedy

   Re-programme dashboard computer

   Build window

   Built 1 Mar 2017 – 1 Nov 2017

   ~379 vehicles affected

6. STEERING COLUMN JOINT MAY NOT BE SECURE

   R/2018/079 · 20 Mar 2018

   20 Mar 2018

   Defect

   The Steering column may become detached from the rack due to incorrectly tightened bolt.

   Remedy

   On affected vehicles check for presence of retaining nut. If present tighten nut to specified torque. If nut is absent replace bolt and screw and tighten to specified torque. THE MANUFACTURER HAS ADVISED NOT TO DRIVE THE VEHICLE

   Build window

   Built 12 May 2016 – 26 Jun 2017

   ~124 vehicles affected

7. SIDE BOARD MAY DETACH

   R/2017/014 · 13 Feb 2017

   13 Feb 2017

   Defect

   It has been identified that the side board hinges may fail. This could result in the detachment of the side board whilst the vehicle is in motion.

   Remedy

   Recall all affected vehicles to install safety reinforcement brackets to the side raves of the body.

   Build window

   Built 1 Jan 2010 – 30 Apr 2015

   ~324 vehicles affected

8. POSSIBLE ENGINE FAILURE / RISK OF FIRE

   R/2016/108 · 31 May 2016

   31 May 2016

   Defect

   On affected vehicles the turbocharger induction pipe may fail allowing oil to leak. Vehicle users may notice a drop in oil level which should also cause the oil warning lamp to illuminate. This may lead to engine failure and In extreme cases a risk of fire.

   Remedy

   On affected vehicles replace the turbocharger oil induction pipe.

   Build window

   Built 9 Sep 2015 – 20 Sep 2015

   ~55 vehicles affected

9. ENGINE POWER AND/OR BRAKING EFFICIENCY MAY BE AFFECTED

   R/2016/001 · 8 Jan 2016

   8 Jan 2016

   Defect

   On affected vehicles the drive to brake vacuum pump may fail. This may cause a loss of brake servo assistance and a hard brake pedal. It may also cause a reduction in engine power.

   Remedy

   Check the manufacture date of the vacuum pump and where necessary replace the pump.

   Build window

   Affected build dates not specified

   ~527 vehicles affected

10. LOSS OF DRIVE

    R/2014/042 · 8 Apr 2014

    8 Apr 2014

    Defect

    The prop shaft to axle flange bolts may not be tightened to the correct torque. The condition could develop noise and vibration and if not corrected loss of drive.

    Remedy

    Recall the vehicles that are likely to be affected to either re torque the prop shaft to axle flange mounting bolts or where necessary replace the nuts and bolts and apply the correct torque.

    Build window

    Built 7 Apr 2010 – 14 Oct 2013

    ~1,145 vehicles affected

11. REAR WHEEL BEARING MAY SHEAR

    R/2011/102 · 17 Aug 2011

    17 Aug 2011

    Defect

    It is possible that the rear wheel bearing has been damaged whilst it was assembled onto the stub axle. This should be identified by excessive noise however in the worst case if not detected it could result in bearing failure and the detachment of the wheel and hub.

    Remedy

    Recall all the affected vehicles and replace the wheel bearings with new items which will have protective sleeves to aid correct installation.

    Build window

    Built 1 Apr 2010 – 16 Apr 2010

    ~218 vehicles affected

12. SPARE WHEEL MAY BECOME DETACHED

    R/2011/074 · 5 Jul 2011

    5 Jul 2011

    Defect

    The spare wheel carrier winch system may allow the spare wheel to be loosely installed after the customer has used the winch. In this condition the spare wheel might move during driving which may damage and eventually break the cable and guiding pin of the winch system. In this worst case the spare wheel would become detached from the vehicle.

    Remedy

    Recall the vehicles that are likely to be affected to replace the complete spare wheel winch system.

    Build window

    Built 1 Apr 2010 – 29 Aug 2010

    ~1,318 vehicles affected

13. REAR AXLE MAY FAIL

    R/2010/167 · 1 Nov 2010

    1 Nov 2010

    Defect

    There is a risk that the nearside rear axle spindle may crack which in the most serious cases will lead to the spindle breaking which dependent on loading could make directional control difficult to maintain.

    Remedy

    Recall the vehicles that are likely to be affected to change the rear axle.

    Build window

    Built 1 Apr 2010 – 16 Apr 2010

    ~228 vehicles affected

14. FRONT SEAT MAY FAIL

    R/2010/168 · 28 Oct 2010

    28 Oct 2010

    Defect

    It has been found that some of the front seat mounting brackets have not been correctly fitted to the seats. The front seat mountings could fail if the fitting brackets have been incorrectly fitted. Vehicle control could be affected.

    Remedy

    Recall the vehicles that are likely to be affected to check and where necessary fit new seat assemblies.

    Build window

    Built 1 Apr 2010 – 9 Jul 2010

    ~965 vehicles affected

15. DRIVERS SEAT MAY DETACH

    R/2009/137 · 2 Dec 2009

    2 Dec 2009

    Defect

    Due to the non-conformity of some welds under situations of extreme braking the driver's seat may detach from the floor fixing.

    Remedy

    Recalled vehicles will have the subject welds and fixing lugs re-welded.

    Build window

    Built 22 Jan 2008 – 18 May 2009

    ~4,591 vehicles affected

16. HANDBRAKE MAY FAIL

    R/2006/123 · 30 Aug 2006

    30 Aug 2006

    Defect

    It is possible that the rear caliper handbrake lever to crack and weaken. In the worst case there is a possibility that the parking brake cables will release.

    Remedy

    Recall the vehicles that are likely to be affected and check the caliper handbrake lever for evidence of a crack. Where a crack exists on the lever the caliper will be replaced.

    Build window

    Built 24 Oct 2005 – 17 Jan 2006

    ~1,023 vehicles affected

17. STEERING WHEEL MOUNTING MAY NOT CONFORM

    R/2004/151 · 30 Sep 2004

    30 Sep 2004

    Defect

    It has been established that in certain cases the tightness of the steering wheel mounting may not be to specification.

    Remedy

    Likely to be affected vehicles will be recalled at which time as a preventative measure the steering wheel will be replaced and it's mounting strengthened.

    Build window

    Built 2 Sep 2003 – 28 May 2004

    ~3,513 vehicles affected

18. RISK OF STALLING

    R/2002/083 · 22 Jul 2002

    22 Jul 2002

    Defect

    The engine may stall at idle and/or when lifting off the throttle following a period of hard acceleration.

    Remedy

    Check the serial number on the fuel pressure regulator and replace it if it is within the affected range.

    Build window

    Built 1 Nov 2000 – 31 May 2001

    ~1,861 vehicles affected

19. POSSIBLE LOSS OF DIRECTIONAL CONTROL

    R/1997/010 · 13 Jun 1997

    13 Jun 1997

    Defect

    Wear in the area of the support bearings may lead to failure of the primary steering shaft and cause loss of directional control.

    Remedy

    The affected vehicles are being recalled to have the original shaft replaced with a complete assembly.

    Build window

    Built 1 Mar 1989 – 30 Apr 1995

    ~12,500 vehicles affected