Fiat
500 C
8,564 MOT tests analysed. lands in the middle of the pack — here's where 500 Cs pass, fail, and end up on the retest sheet.
That's 6.3 points below the UK fleet average across our 1,984 tracked models — buyers should expect more first-time fails than the typical UK car.
Pass
71.2%
Pass-after-fix
4.3%
Fail
24.0%
Avg miles
66,542
Pass + Pass-after-fix + Fail = 100%
Petrol cars first registered from January 2006 meet Euro 4 — compliant in London ULEZ, Birmingham CAZ, Bristol CAZ, and Glasgow LEZ.
The picture
500 C: middle-of-the-pack on first-time pass
Across 5,456 MOT tests, the 500 C returns 70.2% first-time pass — below the UK fleet average. The single most-logged Major fail is worn suspension bushes. A worn shock-absorber bush and shock absorber damaged to the extent round out the top three. Average tested mileage sits at 63,122, which is the lens to read those failure rankings through. If you own one and the next test is close, the ranked list below is a sensible pre-test checklist.
ABI Insurance Group
Group 3–14
A low-group car — among the cheapest to insure in the UK. Lower groups cost less to insure; UK fleet average is around Group 22.
Source: ABI Group Rating Panel · administered by Thatcham Research · groups cover standard variants; performance trims may sit higher. Browse all insurance groups →
3–14
out of 50
Top ten reasons for rejection.
Filter failures:
Hide categories
Tick a category to hide it from rankings sitewide. Saved in this browser only.
- 01
A suspension pin, bush or joint excessively worn
353 occurrences · 4.1% of tests
- 02
A shock absorber bush excessively worn
308 occurrences · 3.6% of tests
- 03
A shock absorber damaged to the extent that it does not function or showing signs of severe leakage
219 occurrences · 2.6% of tests
- 04
Lambda coefficient outside the default limits or the range specified by the manufacturer
170 occurrences · 2.0% of tests
- 05
Windscreen or window damaged or seriously discoloured but not adversely affecting driver's view
154 occurrences · 1.8% of tests
- 06
A transmission shaft constant velocity joint boot severely deteriorated
154 occurrences · 1.8% of tests
- 07
A suspension pin, bush or joint excessively worn
148 occurrences · 1.7% of tests
- 08
Parking brake efficiency below minimum requirement
147 occurrences · 1.7% of tests
- 09
Exhaust system leaking or insecure
134 occurrences · 1.6% of tests
- 10
Tyre tread depth not in accordance with the requirements
119 occurrences · 1.4% of tests
Counts cover Major and Dangerous defects logged at test. Advisory items excluded so this shows why a car was rejected, not just what the tester flagged in passing.
Try the calculator
Build your own retest budget.
My Motor World · affiliate
Parts & supplies for this fix
Affiliate links — small commission, no extra cost to you.
Hycote
Hycote Touch Up Colour Paint Brush Fiat Broom Yellow 12.5ml
£6.59
View at My Motor World →
Hycote
Hycote Fiat Capri Blue Double Acrylic Spray Paint 150ml
£6.59
View at My Motor World →
Hycote
Hycote Fiat Black Double Acrylic Spray Paint 150ml
£6.59
View at My Motor World →
Hycote
Hycote Fiat Red Orange Double Acrylic Spray Paint 150ml
£6.59
View at My Motor World →
Click Mechanic · affiliate
Book a mobile mechanic
Affiliate links — small commission, no extra cost to you.
Mobile mechanic · UK-wide
Book a mechanic at your door.
Fixed-price quotes upfront. No garage needed. Click Mechanic sends a vetted local mechanic to you — home, work, or roadside.
Owner reports · Honest John
What owners actually report.
Verbatim faults logged by owners on honestjohn.co.uk over recent years. We didn't summarise — these are the words people typed in.
What's good
Not very practical. Bouncy ride. Sluggish performance. In-car tech is behind the times.
Recent owner-reported faults
- 14 Oct 2014
Another case of hatchback lock failing because cables inside wiring loom had chafed in the hatchback hinge. All 500 owners should check for this.
- 2 Oct 2014
Software fix available from some Fiat dealers that restores the performance of EU6 1.2 Panda and 500 engines.
- 3 Sep 2014
Fiat 500 Dualogic would not select any gears and required new Actuator at a cost of £1800. Cost of repairs so far: £3,000.
- 17 Aug 2014
Problem with EU6 compliant versions of 1.2 Fire engine in Fiat 500. Hesitation when pulling away in 1st and 2nd gears due to a ECU remapping to meet EU6. "Feels very unsafe, when trying to pull out into traffic."Apparently, some Fiat dealers have an ECU software fix for this. At a guess, it is probably to resture the ECU to the EU5 settings.
- 7 Jul 2014
Another case of a 500 MultiJet diesel engine revving uncontrollably because the ECU had introduced too much fuel to the engine to actively regenerate the DPF, this fuel had sunk into the sump, and the sump level had risen sufficiently for the compression ignition engine to run on it. This car was a 25,000 mile 2008 500 MultiJet. Vital for all drivers of 500 MultiJet diesels to chack their sump levels regularly and if the oil seems to rise get their cars to a Fiat dealership for an oil change and forced regeneration of the DPF.
- 30 Jun 2014
Second report of failed rear wiper and brake lights on a 4-year old 500 due to can bus wiring problems as a result of the cable loom getting trapped in the hatchback opening £400 to fix.
- 20 Apr 2014
A 2010 Abarth 500 suffered the loss of various key functions including speedometer, indicators and brake lights (which of course makes the car illegal to drive). An independent garage traced the fault to the wiring cable under the tailgate. The wires had become twisted and broken as a result of the movement of the tailgate. Fault as origninally reported on 13-5-2012.
- 10 Apr 2014
Heater matrix failure on 500 TwinAir led to overheating of engine.
- 22 Mar 2014
Electric hatch lock failed twice on a 17,500 mile 2009/50 500: first time replaced under warranty; 2nd time dealer wanted £193.
- 18 Feb 2014
Clutch mechanism of 2009/59 500 and electric hatchback lock failed at very low 2500 miles.
- 22 Sep 2013
Yet another failed 1.3 Multijet reported. This was a 2008/58 that had done less than 14,000 miles. Active DPF regeneration had put too much diesel into the engine, effectively raising the sump level and causing the engine to run uncontrollably on its sump oil to the point of self-destruction. Vital for all drivers of 500 Multijet diesels to chack their sump levels regularly and if the oil seems to rise get their cars to a Fiat dealership for an oil change and forced regeneration of the DPF.
- 12 Sep 2013
PAS failure on 20 month old 500C**.**
Source: honestjohn.co.uk · 29 reports indexed, top 12 shown
Buying or keeping a 500 C?
Use the failure ranking as a pre-test checklist or a haggling lever. Treat the headline pass rate as a fleet-wide trend, not a guarantee on any individual car.
If you own a 500 C and your last MOT looked nothing like the ranked failures above, that's normal — individual cars vary widely. The ranking shows the patterns testers flag most often across the country.